Hyundai Equus Manuals

Hyundai Azera: Evaporator Core Repair procedures - Heater - Heating,Ventilation, Air Conditioning - Hyundai Azera 2011-2024 Service ManualHyundai Azera: Evaporator Core Repair procedures

Fifth generation HG (2011–2024) / Hyundai Azera 2011-2024 Service Manual / Heating,Ventilation, Air Conditioning / Heater / Evaporator Core Repair procedures

Replacement
1.
Disconnect the negative (-) battery terminal.
2.
Recover the refrigerant with a recovery/ recycling/ charging station.
3.
When the engine is cool, drain the engine coolant from the radiator.
4.
Remove the heater & blower assembly.
(Refer to Heating,Ventilation, Air Conditioning - "Heater Unit")
5.
Remove the blower unit (B) from heater unit after loosening 3 screws.

6.
Loosen the heater unit lower case mount screw and then remove the heater unit lower case (A).

7.
Remove the evaporator core (A).

   
•
Be careful that the inlet and outlet pipe are not bent during evaporator core removal / installation.
8.
Installation is the reverse order of removal
   
-
If you're installing a new evaporator, add refrigerant oil (ND-OIL8).
-
Replace the O-rings with new ones at each fitting, and apply a thin coat of refrigerant oil before installing them. Be sure to use the right O-rings for R-134a to avoid leakage.
-
Immediately after using the oil, replace the cap on the container, and seal it to avoid moisture absorption.
-
Do not spill the refrigerant oil on the vehicle ; it may damage the paint ; if the refrigerant oil contacts the paint, wash it off immediately
-
Apply sealant to the grommets.
-
Make sure that there is no air leakage.
-
Charge the system and test its performance.
-
Do not interchange the inlet and outlet heater hoses and install the hose clamps securely.
-
Refill the cooling system with engine coolant
Heater Core Repair procedures
Replacement 1. Disconnect the negative (-) battery terminal. 2. Recover the refrigerant with a recovery/ recycling/ charging station. 3. When the engine is cool, drain the engine coola ...

Temperature Control Actuator Components and Components Location
Component Location ...

See also:

Self-diagnosis
When you shift the gear to the R (Reverse) position and if one or more of the below occurs you may have a malfunction in the rear parking assist system. You do not hear an audible warning sound o ...

Smart key unit Repair procedures
Removal     - Take care not to scratch the crash pad and related parts Smart key unit 1. Disconnect the negative (-) battery terminal. 2. Remove the accelerator pedal ...

Oil Pump Components and Components Location
Components 1. Oil pump2. O-ring3. Oil pump sprocket4. Oil pump chain cover ...

Categories

Hyundai Azera Manuals


© 2011-2024 Copyright www.hgmanual.com