Hyundai Equus Manuals

Hyundai Azera: Water pump Repair procedures - Cooling System - Engine Mechanical System - Hyundai Azera 2011-2024 Service ManualHyundai Azera: Water pump Repair procedures

Fifth generation HG (2011–2024) / Hyundai Azera 2011-2024 Service Manual / Engine Mechanical System / Cooling System / Water pump Repair procedures

Removal
1.
Drain the coolant.
(Refer to Cooling System - "Coolant")
2.
Remove the drive belt.
(Refer to Timing System - "Drive Belt")
3.
Remove the water pump pulley (A).

4.
Remove the water pump (A) and gaskets (B).

Installation
Water Pump
1.
Install the water pump (A) with the new gaskets (B).

   
•
Clean the contact face before assemble.
•
Always use a new gaskets.
Tightening torque
A(3EA): 9.8 ~ 11.8N.m (1.0 ~ 1.2kgf.m, 7.2 ~ 8.7lb-ft)
B(1EA): 9.8 ~ 11.8N.m (1.0 ~ 1.2kgf.m, 7.2 ~ 8.7lb-ft)
C(1EA): 21.6 ~ 26.5N.m (2.2 ~ 2.7kgf.m, 15.9 ~ 19.5lb-ft)
D(1EA): 9.8 ~ 11.8N.m (1.0 ~ 1.2kgf.m, 7.2 ~ 8.7lb-ft)
E(1EA): 9.8 ~ 11.8N.m (1.0 ~ 1.2kgf.m, 7.2 ~ 8.7lb-ft)
F(1EA): 9.8 ~ 11.8N.m (1.0 ~ 1.2kgf.m, 7.2 ~ 8.7lb-ft)
G(4EA) :21.6 ~ 23.5N.m (2.2 ~ 2.4kgf.m, 15.9 ~ 17.4lb-ft)

2.
Install the water pump pulley (A).
Tightening torque :
7.8 ~ 9.8N.m (0.8 ~ 1.0kgf.m, 5.8 ~ 7.2lb-ft)

3.
Install the drive belt.
(Refer to Timing System - "Drive Belt")
4.
Fill the radiator with coolant and check for leaks.
Water pump Components and Components Location
Components 1. Water pump pulley2. Water pump 3. Water pump gasket ...

Water pump Troubleshooting
Troubleshooting SymptomsPossible CausesRemedyCoolant leakage • From the bleed hole of the water pump Visually check • Check leaks after about ten-minute warming up. • If coolant st ...

See also:

Turn Signal Lamp Repair procedures
Removal Door mirror turn signal lamp 1. Disconnect the negative (-) battey terminal. 2. Remove the mirror (A). 3. Remove the outside mirror cover (A). 4. Remove the lower cover (A) of ...

Lighting control
The light switch has a Headlight and a Parking light position. To operate the lights, turn the knob at the end of the control lever to one of the following positions: (1) OFF position (2) Park ...

Wheel alignment and tire balance
The wheels on your vehicle were aligned and balanced carefully at the factory to give you the longest tire life and best overall performance. In most cases, you will not need to have your wheels ali ...

Categories

Hyundai Azera Manuals


© 2011-2024 Copyright www.hgmanual.com